Champion Chemical Company
Material Safety Data Sheet

SECTION I: PRODUCT & COMPANY INFORMATION
PRODUCT NAME: FORMULATION CCC 128 (READY TO USE)
PRODUCT NUMBER: RMC #3
PRODUCT TYPE: DISINFECTANT-CLEANER
MANUFACTURER: CHAMPION CHEMICAL COMPANY
8319 S. Greenleaf Avenue
Whittier, CA 90602 USA
Telephone: (800) 621-7868
Fax: (800) 898-8064
Website: www.championchemical.com
TECHNICAL INFO: (800) 621-7868
MEDICAL EMERGENCY: (800) 451-8346 (24 HOURS)
CHEMICAL LEAK/SPILL: CHEMTREC (800) 424-9300 (24 HOURS)
SHIPPING DESCRIPTION CLEANING COMPOUND, LIQUID, N.O.S.
 
NFPA RATING
HMIS RATING
HEALTH
0-MINIMAL
0-MINIMAL
FIRE
0-MINIMAL
 0-MINIMAL
REACTIVITY 0-MINIMAL 0-MINIMAL

SECTION II: HAZARDOUS INGREDIENTS
(Listed when present at 1% or greater, carcinogens at 0.1% or greater) All component chemicals are listed or exempted from listing on the "TSCA Inventory" of chemical substances maintained by the U.S. EnvironmentalProtection Agency.

CHEMICAL NAME(S)

% W

CAS REGISTRY NO.

REFERENCE TABLE

CARCINOGEN

TWA MG/M3

STEL MG/M3

CEILING MG/M 3

DIDECYL DIMETHYL AMMONIUM CHLORIDE

0-1%

7173-51-5

 NOT ESTABLISHED

NOT ESTABLISHED

NOT ESTABLISHED

NO

ALKYL DIMETHYL BENZYL AMMONIUM CHLORIDE

0-1%

8001-54-5

NOT ESTABLISHED

NOT ESTABLISHED

NOT ESTABLISHED

NO

NONYL PHENOL ETHOXYLATE

0-1%

9016-45-9

NOT ESTABLISHED

NOT ESTABLISHED

NOT ESTABLISHED

NO

SECTION III: PHYSICAL DATA

BOILING POINT 212 F VAPOR PRESSURE UNKNOWN
VAPOR DENSITY(AIR= 1) UNKNOWN SOLUBILITY IN WATER COMPLETE
PH 8-9 SPECIFIC GRAVITY (H2O=1) 1.0
EVAPORATION RATE (BUT. ACE.=1) <1 PERCENT SOLID BY WEIGHT 1-2%
PHYSICAL STATE LIQUID  
APPEARANCE & ODOR  NON-VISCOUS RED LIQUID, PLEASANT FRAGRANCE

SECTION IV: FIRE & EXPLOSIVE HAZARD DATA

FlASH POINT  > 200 F METHOD USED ASTM-D56
FlAMMABLE LIMITS N/A FLAME EXTENSION N/A
EXTINGUISHING MEDIA WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
SPECIAL FIRE-FIGHTING PROCEDURES MUST WEAR NIOSH/MSHA APPROVED SELF-CONTAINED BREATHING APPARATUS AND PROTECTIVE CLOTHING. COOL FIRE-EXPOSED CONTAINERS WITH WATER SPRAY.
UNUSUAL FIRE AND EXPLOSIVE HAZARDS PRODUCTS OF COMBUSTION ARE TOXIC

SECTION V: HEALTH HAZARD DATA

THRESHOLD LIMIT VALUE

NOT ESTABLISHED PRIMARY ROUTES OF ENTRY INHALATION, SKIN CONTACT, EYES, ORAL

EFFECTS OF OVEREXPOSURE-CONDITIONS TO AVOID

CORROSIVE:
HARMFUL TO EYES: Causes severe eye damage or irritation with symptoms of pain, redness, swelling of the conjunctiva and possible irreversible eye damage.
HARMFUL TO SKIN: Causes severe skin damage or irritation with symptoms of pain, redness and chemical burns.
HARMFUL IF SWALLOWED: Ingestion can produce immediate pain in the mouth, throat and abdomen; severe swelling of the larynx; skeletal muscle paralysis affecting the ability to breathe, circulatory shock and/or convulsions.
HARMFUL IF INHALED: Inhalation of product mist may cause respiratory irritation.
Do not get in eyes, on skin or clothing. Do not swallow. Avoid breathing product mist.  Wash thoroughly after handling.

CONDITIONS AGGRAVATED BY USE

PREEXISTING SKIN, EYE OR RESPIRATORY DISORDERS

SECTION V: EMERGENCY & FIRST AID PROCEDURES

EYES

Hold eye open and rinse slowly and gently with water for 15-20 minutes. Remove contact lenses after the first 5 minutes then continue rinsing eye. Get immediate medical attention.
SKIN

Take off contaminated clothing. Rinse skin immediately with plenty of water for 15-20 minutes. Get medical attention. Wash contaminated clothing before reuse

INGESTION

Call a poison control center or doctor immediately for treatment advice. Have person sip a glass of water if able to swallow. Do not induce vomiting unless told to do so by the poison control center or doctor. Do not give anything by mouth to an unconscious person. NOTE TO PHYSICIAN: Probable mucosal damage may contraindicate the use of gastric lavage. Measures against circulatory shock, respiratory depression and convulsion may be needed.

INHALATION

In case of respiratory irritation, move person to fresh air. Get medical attention if irritation persists

SECTION VI: REACTIVITY DATA

STABILITY STABLE INCOMPATIBLE MATERIALS STRONG OXIDIZERS
HAZARDOUS DECOMPOSITION PRODUCTS CO, CO2   (MAY ALSO INCLUDE UNIDENTIFIED TOXIC AND/OR IRRITATING COMPOUNDS.)
HAZARDOUS POLYMERIZATION
WILL NOT OCCUR

SECTION VII: SPILL OR LEAK PROCEDURES

Steps to be Taken in Case Material is Released or Spilled:

Dike and contain spill with inert material (sand, earth, etc.) and transfer the liquid and solid separately to containers for recovery and disposal. Keep spill out of sewers and open bodies of water.

Waste Disposal Method:

Dispose of in compliance with all Federal, state and local laws and regulations. Incineration is the preferred method.

SECTION VIII: SPECIAL PROTECTION INFORMATION

RESPIRATORY PROTECTION
 If exposure limits (see Section II) are exceeded or if respiratory irritation occurs, a NIOSH approved respirator suitable for the use conditions and chemicals listed in Section II should be worn.
VENTILATION
 GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT FOR MOST CONDITIONS. LOCAL EXHAUST VENTILATION MAY BE NECESSARY FOR SOME OPERATIONS.
PROTECTIVE GLOVES
RUBBER OR NEOPRENE GLOVES ARE RECOMMENDED TO MINIMIZE SKIN CONTACT.
EYE PROTECTION

SPLASH GOGGLES AND/OR FACE SHIELD WHILE HANDLING CONCENTRATE.

OTHER PROTECTIVE EQUIPMENT

NONE REQUIRED

SECTION IX: SPECIAL PRECAUTIONS

PRECAUTIONS, HANDLING & STORING

KEEP FROM FREEZING. STORE AT TEMPERATURES BELOW 140 F. KEEP CONTAIN CLOSED UNTIL USED. DO NOT CONTAMINATE DRINKING WATER, FOOD OR FEED BY STORAGE OR DISPOSAL. KEEP OUT OF REACH OF CHILDREN.

OTHER PRECAUTIONS

California Proposition 65 Warning: This product contains the following chemicals known to the State of California to cause cancer or birth defects or other reproductive harm: Acetaldehyde; CAS No. 75-07-0 (Trace); Benzene; CAS No. 71-43-2 (Trace); Benzyl chloride; CAS No. 100-44-7 (Trace); N-Nitrosodimethylamine; CAS No. 62-75-9 (Trace); Propylene oxide; CAS No. 75-56-9 (Trace); Toluene; CAS No. 108-88-3 (Trace).

RMC FORMULATION CCC 128

PRODUCT NO. 3

EFFECTIVE DATE

01/20/05

REF: 29 CFR 1910.1200 (OSHA)

 

 

This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty, express or implied, as to the accuracy of the information contained herein. Actual conditions of use and handling are beyond sellerĖs control. User is responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State and Local laws and regulations.